Open Access Open Access  Restricted Access Subscription Access

Experimental Study to Enhance the Performance of Heat Transfer in Fire Tube Boilers

Dr. Basima Salman Khalaf

Abstract


This paper deals with experimental study which is a fixed the corrugated strip plate inside fire box tube (furnace duct), in order to enhanced the performance of heat transfer between the hot gases inside tubes and water outside the tube.As well as to prevent furnace walls by making the combustion hot gases is homogenous hot gases inside the furnace which is cases the high thermal stress. Upon the furnace wall. The results of experimental work gives good indications, this agreement enhance the heat transfer gives long life time and reduce the madding cost of the boiler.


Full Text:

PDF

References


D. R. Dougan, A. D. LaRue, J. J. Wolf. Inline air-coal separator: U.S. Patent 4, 448,135[P]. 1984-5-15.

J. Vatsky, E. S. Schindler. Combustion system andmethod for a coal-fired furnace wide turn-down burner: U.S. Patent 4, 497, 263[P]. 1985-2-5.

Z.Q. Li, R. Sun, L.Z. Chen, Z.X.Wan, S.H. Wu, Y.K. Qin, Effect of primary air flow typeson particle distributions in the near swirl burner region, Fuel 81 (6) (2002)829–835.

H. Zhang, X.Q. Xu, Particulate concentration enrichment of primary air in pulverized coal boilers, China Particuology 2 (5) (2004) 230–233.

S. Xue, S.E. Hui, T.S. Liu, Q.L. Zhou, T.M. Xu, H.L. Hu, Experimental investigation on NOx emission and carbon burnout froma radially biased pulverized coalwhirl burner, Fuel Process. Technol. 90 (9) (2009) 1142–1147.

R. Kurose, M. Ikeda, H. Makino, M. Kimoto, T. Miyazaki, Pulverized coal combustion characteristics of high-fuel-ratio coals, Fuel 83 (13) (2004) 1777–1785.

Z. Chen, Z. Li, J. Jing, F.Wang, L. Chen, S.Wu, The influence of fuel bias in the primary air duct on the gas/particle flow characteristics near the swirl burner region, Fuel Process. Technol. 89 (10) (2008) 958–965.

J.K. Feng, Y.T. Shen, R.C. Yang, Principle and Calculation of Boilers [M], third ed. Beijing: Science Press, 2003 7–13.

W.D. Fan, Z.C. Lin, Y.Y. Li, J.G. Kuang, M.C. Zhang, Effect of air-staging on anthracite combustion and NOx formation, Energy Fuel 23 (2009) 111–120.

J.M. Lee, D.W. Kim, J.S. Kim, Characteristics of co-combustion of anthracite with bituminous coal in a 200-MWe circulating fluidized bed boiler, Energy 36 (2011)


Refbacks

  • There are currently no refbacks.